Hi,how do you check your fuel consumption.

If you check it by the fuel gauge and trip your gauge might be acting up.

francophile1947 wrote:Fuel gauge doesn't go to empty.

Lucky You

Hi,the length of the dip stick is 475mm.From the tip of the stick to the stop above the O ring.

The diff breather..just prise off the cover and check the breather hole,clean out if required then replace the cover.

Hi,
Was it using oil prior to your engine repair.

What is the oil consumption.

Did you scrape all the carbon off the piston heads.

thanks everyone for your help, i think it might be easier to change the injector first, before taking it apart to adjust tappets. definitely comeing from the number one cylinder area just hope its not a bottom end problem Hi, if you take out No1 injector and swap it with No4 injector the noise shou...

markdogwalker wrote:i know its loud , as people on foot are looking when iam turning ,
i know there smart looking vans ??? but not that smart

CV joint thats the most likely suspect.

Hi,
is your bongo 2 wheel drive or 4 wheel drive.

I have just returned from a trip and I am a wee bit concerned about the engine temp. We were towing a small caravan and faced several long steep hills. I have the temp on my alarm set at 120 (the highest it will set too) and it went off on four occasions. Rising to a 124 temp after sounding the ala...

When starting from cold,try listening for the 'click' from totally cold its about a count of 18 after heater light goes out. yes i get a clicking sound, is that good or bad? Hi the clicking sound only means that the relay has been energised,it does not mean that it is working properly ie passing cu...

pretty sure it's not glow plugs as it starts no problem at all,plus i fitted brand new plugs back in march.....once it's started it just doesn't tick over...just splutters and cuts out...once the engine is warm it's fine...cheers Check the voltage at the glow plug rail,it should stay on for about 1...

Hi everyone, We have the oil leak back, we thought it had stopped but now everytime we drive away there is a puddle of oil which runs onto the road from the sump cover (it must gather there whilst stood) then a streak for a few yards as we drive away. We have it booked into our garage but not until...

I'm looking at replacement tyres, and all I can seem to find are Pirelli P7's in the right size and load rating. 215/55/17/96 is what I'm after (came with 17" alloys on) Anyone used P7's - opinions good or bad? Anyone found alternative tyres that size? Might have to go with what I can get, as ...

I'm still not convinced that there is a head problem. The turbo has been mentioned before as a possible problem, as the pipework for it is at the stat housing fitting or removing the thermostat could affect air ingress. If a chat about it would help pm me your land line number. Thanks Mel, I'll giv...

Timbo wrote:thanks - but where is the turbo - to try and gets it's number?

http://www.lushprojects.com/bongopartsm ... mgno=.html

Hi lift the pasengers seat and you will find it on the exhaust manifold.(on the side of the engine)