key out engine runs

daznotts62 · Post by **daznotts62** » Sun Apr 11, 2010 12:59 pm

hi folks,
turning the key to switch off bongo everything seems normal but the engine carries on running , this i assume is not normal!!!!,there is no turbo timer switch or anything like that connected !!!!!!!................any solutions

thanks Daz

missfixit70 · Post by **missfixit70** » Sun Apr 11, 2010 1:04 pm

Sounds like the cut off solenoid on the fuel pump is jamming open. Make sure connections are tight first, 24-3002 on here - http://www.lushprojects.com/bongopartsm ... o=.html#20

mikexgough · Post by **mikexgough** » Sun Apr 11, 2010 1:09 pm

is it a diesel?..... if so your stop valve isn't working..... it is on the diesel pump... bosch number.... 9 461 612 134
if it's petrol.....

Part numbers

Diagram

gmaczbongo · Post by **gmaczbongo** » Sun Apr 11, 2010 5:44 pm

Check that it is not hanging loose on the threads.
Also - ignition on and disconnect the wire and see if you hear it clicking.
With engine running disconnect the solenoid wire and see if it shuts down.
If not, it is stuck open and needs replacing.

daznotts62 · Post by **daznotts62** » Mon Apr 12, 2010 8:37 am

thanks folks,

will have a look later

regards

You've Been Bongod · Post by **You've Been Bongod** » Mon Apr 12, 2010 9:00 am

if its a petrol sounds like timing out if diesel ??????????????????????????????????

321Away · Post by **321Away** » Mon Apr 12, 2010 12:42 pm

just cos you cant see a turbo timer doesnt mean there's not 1 tucked up behind a panel somewhere, i've seen literally hundreds of the starbo remote start type units with built in turbo timer, when you pull the key out and the engine runs on, try releasing the handbrake, as any properly installed timer will cut out as soon as the brake is released.
Julian

markdogwalker · Post by **markdogwalker** » Mon Apr 12, 2010 8:08 pm

my bongo has a three way switch that says slow , off , long
i never knew what it was until i took the key out one day and the engine kept running

i must have switched it on by mistake when cleaning it
its on some kind of timer, it beeps lightly and runs on for about five minutes at a guess ,
i still dont know what its for ,
came in handy during the winter for clearing the ice

has yours got the same switch on the left of the steering wheel

mikexgough · Post by **mikexgough** » Wed Apr 14, 2010 7:52 pm

If it's the solenoid and not a Turbo timer..... http://flag-diesel.rivousel.com/FlagDiesel/index.htm these guys do them for £10....

key out engine runs

key out engine runs

Re: key out engine runs

Re: key out engine runs

Re: key out engine runs

Re: key out engine runs

Re: key out engine runs

Re: key out engine runs

Re: key out engine runs

Re: key out engine runs