OH DEAR WHAT DAMAGE HAVE I DONE

jaylee · Post by **jaylee** » Mon Oct 08, 2012 7:08 pm

In fairness you may only need to jiggle out part 61-896 http://lushprojects.com/bongopartsmk2/c ... mgno=.html

The fan housing (far right under your hanging controller.) from memory is the two screws on the top (you can see em on that tab bit.) & a bolt to the side of the floor

to remove separately by kind of wiggling it from the side duct to the evaporator & heater housing?? That will just leave the main air con & heater unit with the flaps in to remove.... Bracket from fan unit to the floor pictured here..! http://lushprojects.com/bongopartsmk2/c ... mgno=.html

I don't envy you....

Colin H F · Post by **Colin H F** » Mon Oct 08, 2012 7:19 pm

Hi Simon Jay, cheers guys Jay the upright section should be easy there is a lot of play in it and it actually lifts up and clears the housing, so Simon I don't think I will have to take any more trim off,

jaylee · Post by **jaylee** » Mon Oct 08, 2012 7:21 pm

I think there is a third floor bracket you have not exposed under the after-market flooring far right..?

Post by **Simon Jones** » Mon Oct 08, 2012 7:22 pm

You'll probably be ok. I didn't have the luxury of a sodding great hole cut out of my panel through which to remove it

. Watch out for coolant and A/C oil when you lift it up as it will dribble out the holes below.

jaylee · Post by **jaylee** » Mon Oct 08, 2012 7:31 pm

I'm going to be a bit cocky here,

& air on just removing the top part of the heater housing by removing the multiple fiddly clips then replacing the evaporator in situ....? That way you still have a drivable vehicle without the arse end of the coolant system removed too...!??

Colin H F · Post by **Colin H F** » Mon Oct 08, 2012 7:41 pm

Yeah ideally that is what I'd like to do, to eliminate coolant bleeding issues but not sure if I can access the clips with the unit in the well

jaylee · Post by **jaylee** » Mon Oct 08, 2012 7:52 pm

Yep these 61-A09's are a pain especially on the outer skin side.... http://lushprojects.com/bongopartsmk2/c ... mgno=.html

Take it slow & steady either way, the heater housing isn't that "robust".....

Colin H F · Post by **Colin H F** » Mon Oct 08, 2012 8:09 pm

Are they plastic or metal I am thinking of making a tool to un clip them and hold them so the don't drop down

jaylee · Post by **jaylee** » Mon Oct 08, 2012 8:15 pm

METAL... It maybe a little easier to retrieve them if they do drop when the top half of the heater housing is removed..?? I don't know.. A magnet ended rod will pull to anything down there...!

Colin H F · Post by **Colin H F** » Mon Oct 08, 2012 8:21 pm

Yep exactly what I had in mind

jaylee · Post by **jaylee** » Mon Oct 08, 2012 8:30 pm

I think from memory.... I kind of scooted anything i dropped down there to the right hand side with a stick & because the fan housing alone was removed, i could get my hand in the sill cavity space & retrieve....?

Colin H F · Post by **Colin H F** » Mon Oct 08, 2012 8:44 pm

With a bit of luck I'll find the pesky washer that started all this

jaylee · Post by **jaylee** » Mon Oct 08, 2012 9:05 pm

Forgot all about the reason why....!

Some times it is better to let things go... Why do you think i have a jiffy bag full of spare panel trim clips....

Northern Bongolow · Post by **Northern Bongolow** » Mon Oct 08, 2012 9:36 pm

Colin H F wrote:whats going on here same photo different prices and different eBayers !!!!!!!!!!!!!!!!!!!!

http://www.ebay.co.uk/itm/261072148903? ... 49#ht_791w

http://www.ebay.co.uk/itm/290774142269? ... 500wt_1414

same seller. married i believe. very good family run business, and good bongo parts.

.

Colin H F · Post by **Colin H F** » Mon Oct 08, 2012 10:37 pm

but why two different prices & P&P for the same item nearly £18 difference

OH DEAR WHAT DAMAGE HAVE I DONE

Re: OH DEAR WHAT DAMAGE HAVE I DONE

Re: OH DEAR WHAT DAMAGE HAVE I DONE

Re: OH DEAR WHAT DAMAGE HAVE I DONE

Re: OH DEAR WHAT DAMAGE HAVE I DONE

Re: OH DEAR WHAT DAMAGE HAVE I DONE

Re: OH DEAR WHAT DAMAGE HAVE I DONE

Re: OH DEAR WHAT DAMAGE HAVE I DONE

Re: OH DEAR WHAT DAMAGE HAVE I DONE

Re: OH DEAR WHAT DAMAGE HAVE I DONE

Re: OH DEAR WHAT DAMAGE HAVE I DONE

Re: OH DEAR WHAT DAMAGE HAVE I DONE

Re: OH DEAR WHAT DAMAGE HAVE I DONE

Re: OH DEAR WHAT DAMAGE HAVE I DONE

Re: OH DEAR WHAT DAMAGE HAVE I DONE

Re: OH DEAR WHAT DAMAGE HAVE I DONE